FSIS Proposes New Labeling Rules for Mechanically Tenderized Beef Products

June 6, 2013 08:20 AM

USDA agency's proposed requirements will help ensure that consumers have effective tools and information to protect against foodborne illness.

Source: FSIS news release

USDA’s Food Safety and Inspection Service (FSIS) is proposing new requirements for labeling beef products that have been mechanically tenderized, including adding new cooking instructions, so that consumers can safely enjoy those products.

"Ensuring that consumers have effective tools and information is important in helping them protect their families against foodborne illness," said Under Secretary Elisabeth Hagen. "This proposed rule would enhance food safety by providing clear labeling of mechanically-tenderized beef products and outlining new cooking instructions so that consumers and restaurants can safely prepare these products."

To increase tenderness, some cuts of beef go through a process known as mechanical tenderization, during which they are pierced by needles or sharp blades in order to break up muscle fibers. Research has shown that this process may transfer pathogens present on the outside of the cut to the interior. Because of the possible presence of pathogens in the interior of the product, mechanically tenderized beef products may pose a greater threat to public health than intact beef products, if they are not cooked properly.

The proposed rule would require that mechanically tenderized product is labeled so that consumers know they are purchasing product that has been mechanically tenderized. The rule would also require the labels of mechanically tenderized product to display validated cooking instructions, so that consumers have the information they need to cook this product in a way that destroys illness-causing pathogens.

In a media call this morning, FSIS said that, if accepted, the requirement would take effect in January 2016. The agency has calculated an aggregate cost of $1.05 million to the beef industry to comply with new labeling requirements. Some 26% of raw beef products are mechanically tenderized.

The proposed requirement applies only to beef products. Turkey, pork, lamb and poultry products are not part of the new rule.

Since 2003, the Centers for Disease Control and Prevention has received reports of five outbreaks attributable to needle or blade tenderized beef products prepared in restaurants and consumers' homes. Failure to thoroughly cook a mechanically tenderized raw or partially cooked beef product was a significant contributing factor in all of these outbreaks. In developing this proposed rule, FSIS used data from its own research, from the Agricultural Research Service, and from the CDC to determine the public health risk associated with undercooking mechanically tenderized products, and the benefits of the proposed rule.

The proposal was posted today on the FSIS website and soon will publish in the Federal Register.

The comment period will end 60 days after the proposal publishes in the Federal Register and must be submitted through the Federal eRulemaking Portal at www.regulations.gov, or by mail to the U.S. Department of Agriculture (USDA), FSIS, OPPD, RIMD, Docket Clearance Unit, Patriots Plaza III, Room 8-164, 355 E Street, S.W., Washington, D.C. 20024-3221. All items submitted by mail or electronic mail must include the Agency name and docket number, which will be assigned when it is published in the Federal Register.

Established in 1988, NACMCF formulates scientific advice on the development of microbiological criteria, the review and evaluation of epidemiological and risk assessment data and methodologies for assessing microbiological hazards in foods. The committee provides recommendations to the Secretaries of Agriculture and Health and Human Services (HHS) on microbiological criteria by which the safety and wholesomeness of food can be assessed.

Back to news



Spell Check

6/11/2013 02:23 PM

   Why is such garbage allowed to be sold as beef? If the beef is so tough that it needs to be poked with needles so that someone can eat it, it should have been made into hamburg and sold at Taco Bell. Instead we allow it to be “tenderized” and contaminated. Is it any wonder people are trusting the beef industry less and less?


Corn College TV Education Series


Get nearly 8 hours of educational video with Farm Journal's top agronomists. Produced in the field and neatly organized by topic, from spring prep to post-harvest. Order now!


Market Data provided by QTInfo.com
Brought to you by Beyer